Service Information and Revisions
RV-10 Service Bulletins
ID
Date Posted
Applies To
Description
Details
ID
SB-00080 REV 2
Date Posted
February 15, 2024
Applies To
All RVs using EA-00002 Oil Cooler
Description
Inspection of EA-00002 Oil Cooler for Possible Leaks
Advises owners to read the Airflow Systems service documentation, which directs inspection for possible leaks on a list of specific serial-number Airflow Systems 2006 X-Series oil coolers (Van's part number EA-00002). Commonly installed as default equipment on the RV-14/14A but may have been installed on other RV models, as well. Rev 2 of this document adds an image and video link, directing owners to install fittings with two wrenches to avoid damage to the cooler.
Advises owners to read the Airflow Systems service documentation, which directs inspection for possible leaks on a list of specific serial-number Airflow Systems 2006 X-Series oil coolers (Van's part number EA-00002). Commonly installed as default equipment on the RV-14/14A but may have been installed on other RV models, as well. Rev 2 of this document adds an image and video link, directing owners to install fittings with two wrenches to avoid damage to the cooler.
ID
SB-00090
Date Posted
November 6, 2023
Applies To
All RVs equipped with SV-AP-PANEL
Description
Dynon SV-AP-PANEL Runaway Trim
Directs all owners of aircraft equipped with a Dynon SV-AP-PANEL autopilot control panel to read and review the published Dynon service bulletin document.
Directs all owners of aircraft equipped with a Dynon SV-AP-PANEL autopilot control panel to read and review the published Dynon service bulletin document.
ID
SB-00043
Date Posted
September 6, 2023
Applies To
RV-10 and RV-14
Description
RV-10 & RV-14 elevator skin cracks
Describes inspection for potential elevator cracks and remediation on RV-10/RV-14, as well as preventative steps.
Describes inspection for potential elevator cracks and remediation on RV-10/RV-14, as well as preventative steps.
ID
SB-00036 REV 3
Date Posted
February 28, 2023
Applies To
RV-3/4/6/7/8/9/10/14
Description
Inspect outboard elevator hinge on the horizontal stabilizer rear spar, replace if cracks found
Requires inspection of outboard elevator hinge bracket area on rear spar of horizontal stabilizer for cracks. If cracks are found, repair and replace outboard hinge brackets with new parts.
Requires inspection of outboard elevator hinge bracket area on rear spar of horizontal stabilizer for cracks. If cracks are found, repair and replace outboard hinge brackets with new parts.
ID
SB-00066
Date Posted
October 21, 2022
Applies To
All RVs with Andair fuel pumps
Description
Prohibited use of ethanol in Andair fuel pumps
Informs owners of Andair Service Alert document, which prohibits the use of ethanol-based fuels in aircraft with Andair fuel pumps.
Informs owners of Andair Service Alert document, which prohibits the use of ethanol-based fuels in aircraft with Andair fuel pumps.
ID
SB-00002
Date Posted
November 5, 2020
Applies To
RV-10
Description
Bottom Rudder Hinge Bracket Replacement
Describes change to RV-10 bottom rudder hinge bracket and method for inspection.
Describes change to RV-10 bottom rudder hinge bracket and method for inspection.
ID
SB-00006
Date Posted
May 6, 2020
Applies To
All RV models
Description
Potential leaking of Kavlico pressure sensors
ID
SB 19-09-09
Date Posted
February 26, 2020
Applies To
RV-10
Description
RV-10 updated nose gear leg
ID
SB 18-05-21
Date Posted
May 21, 2018
Applies To
All fuel injected Lycoming engine installations
Description
Proper installation of gauge plug in fuel spider
ID
SB 18-03-30
Date Posted
March 30, 2018
Applies To
RV-10
Description
Elevator control stop inspection
ID
MT SB 31
Date Posted
August 29, 2016
Applies To
All MT governors listed by type and serial number on page 3 and 4 which were manufactred from April 2010 until July 2013 installed on direct drive engines modified with electronic ignition or higher compression pistons.
Description
Flyweight failures
ID
SB 16-03-28
Date Posted
March 28, 2016
Applies To
All RV-3,4,6,7,8,9,10,14
Description
Cracking of wing aft spar web at the inboard aileron hinge bracket attach rivets.
ID
SB 14-12-22
Date Posted
December 22, 2014
Applies To
RV-6A,7A,8A,9A,10
Description
Nose Stop Flange Installation (before further flight)
ID
SB 14-8-29
Date Posted
August 29, 2014
Applies To
RV-10
Description
Engine Mount Elastomer Plate
ID
SB 11-9-13
Date Posted
September 13, 2011
Applies To
All RV Models
Description
Fuel Tank Slosh Inspection
ID
SB 10-1-4
Date Posted
January 4, 2010
Applies To
RV-10
Description
Install Door Safety Latch
ID
SB 08-6-1
Date Posted
June 1, 2008
Applies To
All RV-10 kits and completed aircraft
Description
F-1010 bulkhead reinforcement
ID
SB 07-4-12
Date Posted
April 12, 2007
Applies To
All RV models with electric flaps
Description
Securing flap motor rod end bearing
ID
SB 06-9-20
Date Posted
September 20, 2006
Applies To
All builders and operators of any model of a Van's Aircraft
Description
Trim Cable Anchor
ID
SB 06-2-3
Date Posted
February 3, 2006
Applies To
RV-10
Description
RV-10 Vertical Stabilizer
ID
SB 04-2-1
Date Posted
February 1, 2004
Applies To
Fuel Tanks
Description
Inspect Fuel Tanks
ID
SB 02-12-1
Date Posted
December 1, 2002
Applies To
Firewall Forward Kits and Pre-manufactured hose assemblies purchased prior to December 10, 2002
Description
Inspect Hoses
ID
SB 96-10-1
Date Posted
October 1, 1996
Applies To
All RV Aircraft except RV-12 and RV-14
Description
Filtered Airbox
