Service Information and Revisions
RV-12iS Safety Directives and Alerts
ID
Date Posted
Applies To
Description
Details
ID
SD-00107
Date Posted
December 24, 2024
Applies To
RV-12iS with certain ROTAX 912iS Sport engine serial numbers
Description
Inspection and/or Replacement of Oil Spray Nozzle for ROTAX Aircraft Engines
Safety Directive published to ensure RV-12iS owners are aware of a ROTAX service bulletin affecting 912iS Sport aircraft engines with specific serial numbers. Refer to the ROTAX document for the list of affected serial numbers and inspection details.
Safety Directive published to ensure RV-12iS owners are aware of a ROTAX service bulletin affecting 912iS Sport aircraft engines with specific serial numbers. Refer to the ROTAX document for the list of affected serial numbers and inspection details.
ID
SD-00083
Date Posted
May 15, 2023
Applies To
RV-12iS with fuel pumps in specified serial number range
Description
Replacement of electrical fuel pump(s) for ROTAX Aircraft Engines
Refers owners to Rotax service documents SB-912i-013/SB-912i-013iS, related to possible manufacturing defect in Rotax fuel pumps. Supersedes previous Van's service documents SD 19-12-03 and SB-00056.
Refers owners to Rotax service documents SB-912i-013/SB-912i-013iS, related to possible manufacturing defect in Rotax fuel pumps. Supersedes previous Van's service documents SD 19-12-03 and SB-00056.
ID
SD-00001
Date Posted
July 8, 2020
Applies To
RV-12 and RV-12iS
Description
Safety Directive: Covers the examination, modification and possible replacement of trim motor units installed for elevator trim control.
ID
SD 19-12-03
Date Posted
December 6, 2019
Applies To
RV-12iS with Rotax 912 iS Sport engines
Description
Superseded by SD-00083
RV-12iS Service Bulletins
ID
Date Posted
Applies To
Description
Details
ID
SB-00103
Date Posted
July 11, 2024
Applies To
All RVs with Dynon Skyview software v16.7 or later and canopy latch warning system installed
Description
Dynon Canopy Warning Software/Settings
Directs owners/operators of Dynon Skyview-equipped aircraft with canopy-open warning features to update the Skyview settings files, available on the Van's Aircraft website downloads page, for aircraft with EFIS systems that are updated to Skyview software v16.7 or later, to correct incorrect audible/visual warnings from being annunciated at incorrect RPM speeds.
Directs owners/operators of Dynon Skyview-equipped aircraft with canopy-open warning features to update the Skyview settings files, available on the Van's Aircraft website downloads page, for aircraft with EFIS systems that are updated to Skyview software v16.7 or later, to correct incorrect audible/visual warnings from being annunciated at incorrect RPM speeds.
ID
SB-00102
Date Posted
June 24, 2024
Applies To
RV-12 and RV-12iS
Description
Control Stick Pushrod Inspection
Directs aircraft owners/operators to inspect the control stick pushrod assembly and connections before further flight.
Directs aircraft owners/operators to inspect the control stick pushrod assembly and connections before further flight.
ID
SB-00095 R1
Date Posted
April 26, 2024
Applies To
RV-12 and RV-12iS
Description
RV-12, RV-12iS Stall speed amendment
Describes amendments to the RV-12 and RV-12iS POH documents related to calibrated vs. indicated stall airspeeds
Describes amendments to the RV-12 and RV-12iS POH documents related to calibrated vs. indicated stall airspeeds
ID
SB-00088 Rev 2
Date Posted
April 8, 2024
Applies To
RV-12iS
Description
RV-12iS Radiator Attachment Modification
Directs owners to inspect the RV-12iS radiator, attachment, and surrounding space; includes instructions to replace/modify the radiator mounting hardware. Revision 2 includes clarified steps and figures.
Directs owners to inspect the RV-12iS radiator, attachment, and surrounding space; includes instructions to replace/modify the radiator mounting hardware. Revision 2 includes clarified steps and figures.
ID
SB-00090
Date Posted
November 6, 2023
Applies To
All RVs equipped with SV-AP-PANEL
Description
Dynon SV-AP-PANEL Runaway Trim
Directs all owners of aircraft equipped with a Dynon SV-AP-PANEL autopilot control panel to read and review the published Dynon service bulletin document.
Directs all owners of aircraft equipped with a Dynon SV-AP-PANEL autopilot control panel to read and review the published Dynon service bulletin document.
ID
SB-00059 Rev 1
Date Posted
February 8, 2023
Applies To
RV-12 and RV-12iS
Description
Canopy Latch Block Improvement
A replacement canopy latch block has been designed that prevents the canopy latch from being moved past the edge of the block. Revision 1 adds coverage for those legacy RV-12 aircraft with previously-released canopy latch upgrade installed.
A replacement canopy latch block has been designed that prevents the canopy latch from being moved past the edge of the block. Revision 1 adds coverage for those legacy RV-12 aircraft with previously-released canopy latch upgrade installed.
ID
SB-00073
Date Posted
February 3, 2023
Applies To
RV-12 and RV-12iS with affected G3X avionics kits
Description
Notification of Garmin Service Bulletin for G3X Touch Displays
This bulletin directs customers to obtain and implement a Garmin service bulletin related to the G3X Touch, which refers to a mandatory safety update for those running older versions of the G3X Touch software.
This bulletin directs customers to obtain and implement a Garmin service bulletin related to the G3X Touch, which refers to a mandatory safety update for those running older versions of the G3X Touch software.
ID
SB-00064
Date Posted
January 23, 2023
Applies To
RV-12 and RV-12iS
Description
Cylinder #1 Exhaust Tube Flat Spring Installation
Addition of flat spring parts to the #1 exhaust tube to address potential for slip join separation and/or contact with cowl
Addition of flat spring parts to the #1 exhaust tube to address potential for slip join separation and/or contact with cowl
ID
SB-00067
Date Posted
January 23, 2023
Applies To
RV-12 and RV-12iS
Description
Stabilator Mass Balance Reinforcement
Reinforcement of the WD-1223 Counterbalance Arm to prevent potential fatigue failure
Reinforcement of the WD-1223 Counterbalance Arm to prevent potential fatigue failure
ID
SB 13-3-21
Date Posted
December 20, 2022
Applies To
RV-12 and RV-12iS
Description
Ethanol in Gasoline
Revision 1 - Added RV-12iS to affected models and updates text/links
Revision 1 - Added RV-12iS to affected models and updates text/links
ID
SB-00058
Date Posted
October 19, 2022
Applies To
RV-12iS
Description
HIC Module Replacement
Revision 1: corrects erroneous reference to POH procedures; Bulletin covers RV-12iS HIC module replacement to address potential fuel pump electrical continuity issue (Supersedes SB-00041)
Revision 1: corrects erroneous reference to POH procedures; Bulletin covers RV-12iS HIC module replacement to address potential fuel pump electrical continuity issue (Supersedes SB-00041)
ID
SB-00057
Date Posted
May 19, 2022
Applies To
RV-12 and RV-12iS with certain Dynon HDX displays
Description
Dynon SB: Experimental Skyview HDX Displays Equipped with WiFi
Refers to mandatory completion of Dynon’s Technical Service Bulletin: “Experimental Skyview HDX Displays Equipped with WiFi” - Refer to the Dynon service bulletin document for affected Skyview HDX serial numbers.
Refers to mandatory completion of Dynon’s Technical Service Bulletin: “Experimental Skyview HDX Displays Equipped with WiFi” - Refer to the Dynon service bulletin document for affected Skyview HDX serial numbers.
ID
SB-00056
Date Posted
May 19, 2022
Applies To
RV-12iS with 912iS Sport engines
Description
Rotax SB: Replacement of Electrical Fuel Pump(s) for ROTAX Aircraft Engines
Superseded by SD-00083
Superseded by SD-00083
ID
SB-00053
Date Posted
February 16, 2022
Applies To
RV-12 and RV-12iS
Description
Tailcone Skin Stiffening Clips
Directs RV-12/12iS owners to inspect tailcone skins for cracks, install stiffeners.
Directs RV-12/12iS owners to inspect tailcone skins for cracks, install stiffeners.
ID
SB-00041
Date Posted
December 30, 2021
Applies To
RV-12iS with avionics kits shipped prior to September, 2021
Description
HIC Module Strain Relief Inspection
Superseded by SB-00058
Superseded by SB-00058
ID
SB-00049
Date Posted
September 15, 2021
Applies To
RV-12 and RV-12iS with 912 ULS engines
Description
RV-12 Carburetor Support Spring
This Van's Aircraft service bulleting references related Rotax service bulletin documentation for aircraft equipped with a carbureted Rotax 912 engine.
This Van's Aircraft service bulleting references related Rotax service bulletin documentation for aircraft equipped with a carbureted Rotax 912 engine.
ID
SB-00045
Date Posted
August 30, 2021
Applies To
RV-12iS with 912iS Sport engines
Description
Lock Washer on Generator Wiring Clamp
Lock washer on Generator Wiring Clamp (refers to Rotax Service Bulletin)
Lock washer on Generator Wiring Clamp (refers to Rotax Service Bulletin)
ID
SB-00028
Date Posted
June 15, 2021
Applies To
RV-12 and RV-12iS with affected G3X avionics kits
Description
RV-12 G3X Noise-Induced Erroneous Attitude
Directs owners of aircraft with certain G3X avionics kits to assess ADAHRS performance and install isolators on aircraft where issues are observed.
Directs owners of aircraft with certain G3X avionics kits to assess ADAHRS performance and install isolators on aircraft where issues are observed.
ID
SB 19-10-10
Date Posted
June 2, 2021
Applies To
RV-12iS Powerplant kits delivered prior to Oct 10, 2019 and SLSA aircraft 12076-12080
Description
SB 19-10-10
RV-12iS Fuel system double banjo bolt; Rev 1 reflects change to crush washer part number used.
RV-12iS Fuel system double banjo bolt; Rev 1 reflects change to crush washer part number used.
ID
SB-00013 Rev 1
Date Posted
May 6, 2021
Applies To
RV-12iS
Description
Cracking of the EX-00021 Cylinder #1 and EX-00022-1 Cylinder #2 exhausts
Inspection and remediation steps described related to potential cracking of exhaust tubes (Rev 1: Updated installation instructions)
Inspection and remediation steps described related to potential cracking of exhaust tubes (Rev 1: Updated installation instructions)
ID
SB 19-08-26 Rev 2
Date Posted
February 24, 2021
Applies To
RV-12/RV-12iS with finish kits shipped before 06-10-19
Description
WD-1201 Nose gear leg replacement
WD-1201 Nose gear leg replacement - Revision 2 dated 02/24/2021 modifies required-action timeline to be based on parts availability.
WD-1201 Nose gear leg replacement - Revision 2 dated 02/24/2021 modifies required-action timeline to be based on parts availability.
ID
SB-00023
Date Posted
November 20, 2020
Applies To
RV-12 and RV-12iS aircraft specified in the service letter
Description
WD-1221 Engine Mount Standoff inspection/replacement
Specifies inspection and replacement of WD-1221 Engine Mount Standoff
Specifies inspection and replacement of WD-1221 Engine Mount Standoff
ID
SB-00006
Date Posted
May 6, 2020
Applies To
All RV models
Description
Potential leaking of Kavlico pressure sensors
ID
SB 20-03-16
Date Posted
March 18, 2020
Applies To
ELSA RV-12iS aircraft with Garmin IFR Avionics Kits
Description
Revision 1: Updated to clarify scope of applicability. Covers inspection of AV-60000 terminals on RV-12iS aircraft, references updated kit assembly instructions pages.
ID
SB 20-01-17
Date Posted
February 5, 2020
Applies To
RV-12 and RV-12iS
Description
Safety Wire Engine Plugs
ID
SB 19-08-16
Date Posted
January 13, 2020
Applies To
RV-12iS with AV-60000/60009 module production dates prior to 9/30/2019; SLSA S/N 12076-12081
Description
Describes steps to inspect and photograph electronic modules on certain RV-12iS aircraft in order to determine whether the soldering of components is correct.
ID
SB 19-10-11
Date Posted
October 22, 2019
Applies To
Rotax 912 iS Sport engines listed in the Rotax service bulletin
Description
Rotax Service Bulletin: Fuel Pump Replacement
[Superseded by SD 19-12-03]
ID
SB 19-07-29
Date Posted
August 13, 2019
Applies To
RV-12 and RV-12iS aircraft with certain Rotax 912 ULS engine serial numbers
Description
Notification to RV-12/12iS customers, with Rotax 912 ULS engines and specified ranges of engine serial numbers, of Rotax-issued service bulletin regarding replacement of a circlip on the engine installation.
ID
SB 18-02-03
Date Posted
February 3, 2018
Applies To
All RV-12 aircraft; RV-12iS with earlier tail kit may be affected depending on tail kit ship date
Description
Anti-Servo Tab cracks
ID
SB 18-02-02
Date Posted
February 2, 2018
Applies To
All RV-12 aircraft; RV-12iS with earlier tail kit may be affected depending on tail kit ship date
Description
Potential cracking in the horizontal stabilator front spar
ID
SB 16-08-01
Date Posted
August 1, 2016
Applies To
All RV-12 w/ Emp/Tailcone Kits delivered prior to August 1, 2016; All SLSA RV-12 aircraft delivered prior to August 1, 2016
Description
Stabilator Bearing Inspection
ID
SB 14-11-03
Date Posted
November 3, 2014
Applies To
All flying RV-12 aircraft incorporating wing kits shipped prior to December 24, 2014.
Description
RV-12 Wing Skin-to-Spar Rivet Wear
RV-12iS Notifications and Letters
ID
Date Posted
Applies To
Description
Details
ID
SN-00114
Date Posted
May 8, 2025
Applies To
All RV Aircraft
Description
Understanding RV Flight Limits
Important information concerning aircraft limits for operators of RV aircraft.
Important information concerning aircraft limits for operators of RV aircraft.
ID
SN-00062 REV 1
Date Posted
May 8, 2025
Applies To
All RV Aircraft
Description
Warning Regarding Modifications to Van’s Aircraft Designs Using Van’s Aircraft Parts/Materials and/or Third-Party Parts/Materials
Rev 1: Renamed and revised (was SL-00062). Updated for language consistency with newly-published SN-00108.
Rev 1: Renamed and revised (was SL-00062). Updated for language consistency with newly-published SN-00108.
ID
SL-00105
Date Posted
January 7, 2025
Applies To
RV-12 and RV-12iS
Description
Pitot Tube Bushing Adhesion
Directs owners to inspect pitot bushing for adhesion failure and replace, if necessary, at or before the next annual condition inspection.
Directs owners to inspect pitot bushing for adhesion failure and replace, if necessary, at or before the next annual condition inspection.
ID
SL-00091 REV1
Date Posted
November 11, 2023
Applies To
All RV Models
Description
Laser Cut Parts and Certification of Aircraft
Refers reader to the updated Laser-Cut Parts List as well as the Laser-Cut Parts Engineering Evaluation document; and addresses the use and inspection of these parts.
Refers reader to the updated Laser-Cut Parts List as well as the Laser-Cut Parts Engineering Evaluation document; and addresses the use and inspection of these parts.
ID
SL-00070 R1.1
Date Posted
November 7, 2023
Applies To
RV-12 and RV-12iS
Description
Optional Fuel Tank Inspection Fitting
Describes the addition of a fitting to the top of the RV-12 fuel tank to allow for easier inspection of the fuel strainer. Revised 11/7/2023 to include the RV-12iS tank.
Describes the addition of a fitting to the top of the RV-12 fuel tank to allow for easier inspection of the fuel strainer. Revised 11/7/2023 to include the RV-12iS tank.
ID
SL-00072
Date Posted
June 19, 2023
Applies To
RV-12iS
Description
RV-12iS Ignition Module Firmware Update
Optional installation of microcontroller with updated firmware for RV-12iS aircraft ignition module, if the behavior described in the service letter is observed.
Optional installation of microcontroller with updated firmware for RV-12iS aircraft ignition module, if the behavior described in the service letter is observed.
ID
SL-00078 REV 1
Date Posted
May 10, 2023
Applies To
All RV's
Description
Vapor Lock
Discusses risks of vapor lock in high operating temperature environments and when using non-aviation fuels, as well as some information related to prevention and recognition of potential signs of vapor lock. Rev 1 updates scope of applicability to all RV aircraft running MOGAS.
Discusses risks of vapor lock in high operating temperature environments and when using non-aviation fuels, as well as some information related to prevention and recognition of potential signs of vapor lock. Rev 1 updates scope of applicability to all RV aircraft running MOGAS.
ID
SL-00068
Date Posted
January 23, 2023
Applies To
RV-12 and RV-12iS
Description
Optional Stabilator Hinge Spacer Installation
Permanent optional shims available to replace washer spacers and reduce the difficulty of installing/removing the RV-12/12iS stabilator.
Permanent optional shims available to replace washer spacers and reduce the difficulty of installing/removing the RV-12/12iS stabilator.
ID
SL-00063
Date Posted
October 26, 2022
Applies To
RV-12 and RV-12iS
Description
USB Cable Required for Dynon HDX Screen Replacement
Describes the requirement for a new USB cable during replacement of Dynon HDX screens
Describes the requirement for a new USB cable during replacement of Dynon HDX screens
ID
SL-00048
Date Posted
October 21, 2022
Applies To
RV-12 and RV-12iS
Description
RV-12 Roomier Control Stick
Allows the optional retrofit of a "roomier" control stick to RV-12/12iS aircraft with the original WD-1212 control stick
Allows the optional retrofit of a "roomier" control stick to RV-12/12iS aircraft with the original WD-1212 control stick
ID
SL-00055
Date Posted
September 6, 2022
Applies To
RV-12 and RV-12iS with affected G3X avionics kits
Description
Garmin GSA 28 Autopilot Servo Replacement
Describes a wiring change needed if replacing a Garmin GSA 28 autopilot servo with the latest revision of the GSA 28 on RV-12 or RV-12iS with an avionics kit shipped prior to January, 2022.
Describes a wiring change needed if replacing a Garmin GSA 28 autopilot servo with the latest revision of the GSA 28 on RV-12 or RV-12iS with an avionics kit shipped prior to January, 2022.
ID
SL-00060
Date Posted
September 6, 2022
Applies To
All RV Models
Description
Installation and Use of Control Stick Opening Covers
Recommended installation of stick boot covers to prevent potential unsafe operation due to interference with flight controls
Recommended installation of stick boot covers to prevent potential unsafe operation due to interference with flight controls
ID
SL-00047
Date Posted
August 15, 2022
Applies To
All RV models
Description
Brake Caliper O-Ring Improvement
Guidance for replacement of higher temperature O-rings in brake systems used on RV aircraft
Guidance for replacement of higher temperature O-rings in brake systems used on RV aircraft
ID
SL-00010
Date Posted
February 22, 2022
Applies To
RV-12 and RV-12iS (all, optional)
Description
Optional Aithre Shield EX 3.0 Carbon Monoxide Detector
Minor update - Rev 2: Optional Aithre Shield EX 3.0 Carbon Monoxide Detector
Minor update - Rev 2: Optional Aithre Shield EX 3.0 Carbon Monoxide Detector
ID
SL-00034
Date Posted
January 21, 2021
Applies To
RV-12 and RV-12iS with 912 ULS engines
Description
Optional B&C Voltage Regulator Installation
Service letter describing optional installation of available B&C voltage regulator for legacy RV-12 or RV-12iS with ULS engine only
Service letter describing optional installation of available B&C voltage regulator for legacy RV-12 or RV-12iS with ULS engine only
ID
SL-00022
Date Posted
November 20, 2020
Applies To
RV-12iS aircraft specified in the service letter
Description
Flaperon Pivot Guide Spacer
Covers inspection and where applicable, the addition of a spacer washer to the RV-12iS flaperon torque tube assembly
Covers inspection and where applicable, the addition of a spacer washer to the RV-12iS flaperon torque tube assembly
ID
SL-00030
Date Posted
November 10, 2020
Applies To
RV-12 and RV-12iS (all, optional)
Description
Service Letter SL-00030
Covers installation of optional Grove wheels and brakes for RV-12 and RV-12iS
Covers installation of optional Grove wheels and brakes for RV-12 and RV-12iS
ID
SL-00024
Date Posted
October 30, 2020
Applies To
RV-12 and RV-12iS
Description
RV-12 Dynamic Propeller Balance
Revision 1: Modified and clarified time of compliance details; Clarified steps. Instructs owners/builders on the requirement to complete a dynamic balance of the propeller on the RV-12/RV-12iS.
Revision 1: Modified and clarified time of compliance details; Clarified steps. Instructs owners/builders on the requirement to complete a dynamic balance of the propeller on the RV-12/RV-12iS.
ID
SL-00016
Date Posted
August 25, 2020
Applies To
RV-12 and RV-12iS
Description
Garmin Dual Axis Autopilot Option
Allows owners of Garmin-equipped aircraft to install the Garmin Autopilot Servo Option. Also allows optional installation of GMC 305, GMC 307, or GMC 507 Autopilot Control Modules.
Allows owners of Garmin-equipped aircraft to install the Garmin Autopilot Servo Option. Also allows optional installation of GMC 305, GMC 307, or GMC 507 Autopilot Control Modules.
ID
SL-00004
Date Posted
May 14, 2020
Applies To
RV-12iS
Description
Improved fuel system sealing washer
ID
SL-00012
Date Posted
May 5, 2020
Applies To
RV-12iS with Garmin Nav/Com (IFR) Avionics Kit
Description
Connect Garmin GA 26 GPS Antenna to MFD
ID
SL-00011
Date Posted
May 5, 2020
Applies To
RV-12 and RV-12iS (all, optional)
Description
Optional RV-12iS Cockpit Light Dimmer Kit installation in RV-12 or RV-12iS
ID
SL-00009
Date Posted
May 5, 2020
Applies To
RV-12iS with WH-00133, WH-00134, or WH-00136 harnesses shipping prior to Jan. 6, 2020.
Description
912iS Maintenance Port Wiring Update
ID
SL 19-12-31
Date Posted
February 3, 2020
Applies To
RV-12 and RV-12iS (all, optional)
Description
Service Letter allowing installation of Sensenich three-blade propeller on RV-12 and RV-12iS aircraft.
ID
SL 19-10-30
Date Posted
January 15, 2020
Applies To
RV-12iS
Description
Allows installation of optional "blade style" throttle grip in RV-12iS aircraft
ID
N 19-02-28
Date Posted
December 24, 2019
Applies To
RV-12 and RV-12iS
Description
Gun drilled gear legs: Allows original style gear legs to be replaced or upgraded to gun-drilled legs used on current aircraft/kits.
ID
N 18-10-19
Date Posted
December 24, 2019
Applies To
RV-12iS
Description
Garmin G3X Touch Dual Display option - allows the installation of a second co-pilot EFIS screen. Originally published 10/19/2018.
ID
N 18-10-18
Date Posted
December 24, 2019
Applies To
RV-12iS
Description
SkyView Dual Display option - allows the installation of a second co-pilot EFIS screen. Originally published 10/18/2018.
ID
N 18-11-15
Date Posted
December 24, 2019
Applies To
RV-12iS
Description
Dynon dual-axis autopilot - allows the installation of the Skyview Autopilot Servo option and the AP/Knobs Panel option. Originally released 10/15/2018.
ID
N 18-11-14
Date Posted
December 24, 2019
Applies To
RV-12 and RV-12iS
Description
Garmin dual-axis autopilot - allows the installation of the Garmin Autopilot Servo Option and GMC 305 or GMC 307 AP Control Heads. Originally released 10/14/2018.
ID
N 19-10-16
Date Posted
October 29, 2019
Applies To
RV-12 and RV-12iS
Description
Describes installation of optional RV-12/12iS step plugs
ID
N 19-09-03
Date Posted
October 21, 2019
Applies To
RV-12iS
Description
New Item: Optional RV-12iS Oil Cooler Winterization Kit
ID
N 16-10-10
Date Posted
March 11, 2019
Applies To
RV-12, RV-12iS
Description
Wing Tip Light and Landing Light Option - Revised to include changes made for updated lighting kits/wire harnesses for RV-12 and RV-12iS March 2019.
ID
N 18-07-12
Date Posted
July 12, 2018
Applies To
RV-12, RV-12iS
Description
Change to higher pressure rating aux. fuel pump
ID
N 16-12-14
Date Posted
February 1, 2017
Applies To
RV-12, RV-12iS
Description
Angle-Of-Attack Installation
RV-12iS Revisions and Changes
Note: The date in a document’s title will not be the same as the date on which the document is posted. Drawing date represents the date the change was proposed/started. Date posted represents the completion/release date. Some revisions take longer than others to complete. Reasons include complexity, discovery of additional items needing revision, dependencies on other changes, validation/testing, parts fabrication, etc.
Document Key:
KAI = Kit Assembly Instructions (Number in title indicates the plans section number)
MM = Maintenance Manual
POH = Pilot Operating Handbook
PAP = Production Acceptance Procedures
FTS = Flight Training Supplement
ID
Date Posted
Applies To
Description
Details
ID
MM RV-12iS
Date Posted
March 4, 2025
Applies To
RV-12iS
Description
RV-12iS Maintenance Manual (MM)
Updated to R4 to reflect Garmin equipment changes
Updated to R4 to reflect Garmin equipment changes
ID
47iS/U
Date Posted
January 7, 2025
Applies To
RV-12 and RV-12iS
Description
Spinner & Propeller
Changes related to adhesive used when installing pitot bushing with two-blade Sensenich propeller
Changes related to adhesive used when installing pitot bushing with two-blade Sensenich propeller
ID
47AiS/U
Date Posted
January 7, 2025
Applies To
RV-12 and RV-12iS
Description
Three Blade Propeller
Changes related to adhesive used when installing pitot bushing with three-blade Sensenich propeller
Changes related to adhesive used when installing pitot bushing with three-blade Sensenich propeller
ID
POH (PILOT’S OPERATING HANDBOOK)
Date Posted
April 25, 2024
Applies To
RV-12iS
Description
Pilot's Operating Handbook (POH)
Rev 11: Added glide ratio, stall altitude loss information, and other information for UK certification.
Rev 11: Added glide ratio, stall altitude loss information, and other information for UK certification.
ID
PAP RV-12iS
Date Posted
April 8, 2024
Applies To
RV-12iS
Description
RV-12iS Production Acceptance Procedures (PAP)
Updated to Rev 2.5
Updated to Rev 2.5
ID
10iS-U
Date Posted
May 23, 2023
Applies To
RV-12 and RV-12iS
Description
SECTION 10iS: TAILCONE
Changes related to additional clips in tailcone section
Changes related to additional clips in tailcone section
ID
FTS RV-12iS
Date Posted
April 25, 2023
Applies To
RV-12iS
Description
RV-12iS Flight Training Supplement
Changes related to vapor lock information, emergency egress additions, and reformatting for new paper size.
Changes related to vapor lock information, emergency egress additions, and reformatting for new paper size.
ID
Section 5
Date Posted
February 24, 2023
Applies To
All RV Aircraft
Description
GENERAL INFORMATION
Updated with new information
Updated with new information
ID
9iS/U
Date Posted
January 23, 2023
Applies To
RV-12 and RV-12iS
Description
STABILATOR
Miscellaneous changes
Miscellaneous changes
ID
42MiS/U
Date Posted
January 23, 2023
Applies To
RV-12iS
Description
RV-12iS COMMON ELECTRICAL
Changes related to new flap motor and related parts
Changes related to new flap motor and related parts
ID
28iS/U
Date Posted
January 23, 2023
Applies To
RV-12iS
Description
RUDDER PEDALS & BRAKE SYSTEM
Hardware changes made
Hardware changes made
ID
11iS-U
Date Posted
January 23, 2023
Applies To
RV-12 and RV-12iS
Description
RV-12iS EMPENNAGE ATTACHMENT
Changes related to new stabilator hinge spacers
Changes related to new stabilator hinge spacers
ID
48iS-U
Date Posted
January 23, 2023
Applies To
RV=12iS
Description
SECTION 48iS/U: EXHAUST SYSTEM
Updated to include installation of flat exhaust springs on the #1 exhaust tube
Updated to include installation of flat exhaust springs on the #1 exhaust tube
ID
32iS/U
Date Posted
January 23, 2023
Applies To
RV-12iS
Description
FLIGHT CONTROLS
Changes related to flap motor and related part numbers
Changes related to flap motor and related part numbers
ID
24iS/U
Date Posted
January 23, 2023
Applies To
RV-12iS
Description
ROLLOVER STRUCTURE & F-01207 BULKHEAD
Changes made related to canopy latch block
Changes made related to canopy latch block
ID
39iS/U
Date Posted
January 23, 2023
Applies To
RV-12iS
Description
CANOPY
Changes related to installed flap motor and related parts
Changes related to installed flap motor and related parts
ID
42CiS/U
Date Posted
October 4, 2022
Applies To
RV-12iS
Description
DYNON AVIONICS
Changes related to HIC module update
Changes related to HIC module update
ID
44AiS/U
Date Posted
October 4, 2022
Applies To
RV-12iS
Description
Skyview Dual Axis Autopilot
Changes related to HIC module replacement
Changes related to HIC module replacement
ID
53AiS/U
Date Posted
October 4, 2022
Applies To
RV-12iS with Dynon ADS-B In not already installed
Description
DYNON ADS-B IN
Changes related to HIC module update
Changes related to HIC module update
ID
42PiS_12iS
Date Posted
October 4, 2022
Applies To
RV-12iS
Description
RV-12iS GARMIN G3X NAV/COM SYSTEM
Changes related to HIC module replacement
Changes related to HIC module replacement
ID
04_12iS-U
Date Posted
October 4, 2022
Applies To
RV-12iS
Description
RV-12iS Parts Index
Section 4 for RV-12iS - Parts Index update
Section 4 for RV-12iS - Parts Index update
ID
42NiS
Date Posted
October 4, 2022
Applies To
RV-12iS
Description
GARMIN G3X TOUCH AVIONICS
Changes related to HIC module replacement
Changes related to HIC module replacement
ID
53BiS/U
Date Posted
October 4, 2022
Applies To
RV-12iS with Garmin ADS-B In not already installed
Description
RV-12iS GARMIN ADS-B IN
Changes related to HIC module update
Changes related to HIC module update
ID
43BiS/U
Date Posted
October 4, 2022
Applies To
RV-12iS
Description
Skyview Dual Screen
Changes related to HIC module replacement
Changes related to HIC module replacement
ID
23iS/U
Date Posted
September 23, 2022
Applies To
RV-12iS
Description
Change to omit two rivets that are installed with wire guides in KAI Section 42MiS/U
ID
35iS/U
Date Posted
December 2, 2021
Applies To
RV-12iS
Description
Landing Gear and Engine Mount
Changes to install sequence for upper 90-degree fitting on gun-drilled gear legs.
Changes to install sequence for upper 90-degree fitting on gun-drilled gear legs.
ID
13
Date Posted
November 24, 2021
Applies To
RV-12 and RV-12iS
Description
Section 13 - Spar Assembly
Reflects change to tie-down blocks, which are now shipped with the threads already tapped.
Reflects change to tie-down blocks, which are now shipped with the threads already tapped.
ID
38iS/U
Date Posted
November 24, 2021
Applies To
RV-12iS
Description
SECTION 38iS/U: AIRFRAME ASSEMBLY
Changes Made related to the necessary installation of wing root gap seal before flight.
Changes Made related to the necessary installation of wing root gap seal before flight.
ID
50iS/U
Date Posted
May 6, 2021
Applies To
RV-12iS
Description
Added information to assembly instructions to help ensure exhaust clearance to coolant hoses; Improved instructions.
ID
46iS
Date Posted
March 17, 2021
Applies To
RV-12iS with Rotax 912 iS engine
Description
Change to starter cable part number: WH-P158 replaces WH-P155.
ID
46U
Date Posted
January 22, 2021
Applies To
RV-12iS with ULS engine
Description
ULS Engine Installation
Changes related to B&C voltage regulator
Changes related to B&C voltage regulator
ID
37iS/U
Date Posted
December 22, 2020
Applies To
RV-12iS
Description
COWLING
Changes related to new oil door bushing and parts
Changes related to new oil door bushing and parts
ID
36iS/U
Date Posted
November 10, 2020
Applies To
RV-12 and RV-12iS (all, optional)
Description
SECTION 36iS/U: Gear Leg and Wheel Fairings
Updated to reflect available Grove wheels and brakes option
Updated to reflect available Grove wheels and brakes option
ID
49U
Date Posted
October 6, 2020
Applies To
RV-12iS
Description
RV-12iS ULS ENGINE CONTROLS
Changes made related to new throttle return spring retainer part for ULS engine only
Changes made related to new throttle return spring retainer part for ULS engine only
ID
44BiS
Date Posted
October 6, 2020
Applies To
RV-12iS
Description
RV-12iS GARMIN DUAL AXIS AUTOPILOT
Replaced Garmin GMC 307 with Garmin GMC 507 Autopilot Control Module (Garmin Automatic Flight Control System (AFCS) Mode Controller).
Replaced Garmin GMC 307 with Garmin GMC 507 Autopilot Control Module (Garmin Automatic Flight Control System (AFCS) Mode Controller).
ID
27iS
Date Posted
May 14, 2020
Applies To
RV-12iS
Description
Changed fuel system sealing washer
ID
40iS-U
Date Posted
May 5, 2020
Applies To
RV-12iS
Description
Minor changes made to harness part number call-out
ID
55iS/U
Date Posted
October 21, 2019
Applies To
RV-12iS
Description
New section: Oil Cooler Winterization Kit for the RV-12iS (optional)
ID
12iS/U
Date Posted
October 1, 2019
Applies To
All RV-12/12iS aircraft with Finish Kits shipped on or after 02/05/2019
Description
Update for Garmin IFR avionics kit option
ID
01iS/U
Date Posted
October 1, 2019
Applies To
RV-12iS
Description
Update for Garmin IFR avionics kit option
ID
29iS/U
Date Posted
March 7, 2019
Applies To
RV-12iS
Description
FWD UPPER FUSELAGE
Addition of canopy hinge spacer
Addition of canopy hinge spacer
ID
03iS/U 02
Date Posted
February 14, 2019
Applies To
RV-12iS
Description
Changes Made, Page 02
ID
12
Date Posted
December 17, 2018
Applies To
All RV-12/12iS aircraft with Finish Kits shipped prior to 02/05/2019
Description
Changes Made
ID
17
Date Posted
December 17, 2018
Applies To
All RV-12/12iS aircraft
Description
Changes Made: Page 17-02
ID
26iS/U
Date Posted
December 12, 2018
Applies To
RV-12iS
Description
Fuel Tank
Reflects changes made by the manufacturer of the fuel float on the the F-385B and F-385C Fuel Senders.
Reflects changes made by the manufacturer of the fuel float on the the F-385B and F-385C Fuel Senders.
ID
37iS/U
Date Posted
May 10, 2018
Applies To
RV-12iS
Description
Changes Made Superceded by version posted 12/17/2018
