fbpx Skip to content

Service Information and Revisions

Continue to next section

RV-10 Service Bulletins

ID
Date Posted
Applies To
Descrip­tion
Details
ID
SB-00080 REV 2
Date Posted
February 15, 2024
Applies To
All RVs using EA-00002 Oil Cooler
Descrip­tion
Inspection of EA-00002 Oil Cooler for Possible Leaks
Advises owners to read the Airflow Systems service documentation, which directs inspection for possible leaks on a list of specific serial-number Airflow Systems 2006 X-Series oil coolers (Van's part number EA-00002). Commonly installed as default equipment on the RV-14/14A but may have been installed on other RV models, as well. Rev 2 of this document adds an image and video link, directing owners to install fittings with two wrenches to avoid damage to the cooler.
ID
SB-00090
Date Posted
November 6, 2023
Applies To
All RVs equipped with SV-AP-PANEL
Descrip­tion
Dynon SV-AP-PANEL Runaway Trim
Directs all owners of aircraft equipped with a Dynon SV-AP-PANEL autopilot control panel to read and review the published Dynon service bulletin document.
ID
SB-00043
Date Posted
September 6, 2023
Applies To
RV-10 and RV-14
Descrip­tion
RV-10 & RV-14 elevator skin cracks
Describes inspection for potential elevator cracks and remediation on RV-10/RV-14, as well as preventative steps.
ID
SB-00036 REV 3
Date Posted
February 28, 2023
Applies To
RV-3/4/6/7/8/9/10/14
Descrip­tion
Inspect outboard elevator hinge on the horizontal stabilizer rear spar, replace if cracks found
Requires inspection of outboard elevator hinge bracket area on rear spar of horizontal stabilizer for cracks. If cracks are found, repair and replace outboard hinge brackets with new parts.
ID
SB-00066
Date Posted
October 21, 2022
Applies To
All RVs with Andair fuel pumps
Descrip­tion
Prohibited use of ethanol in Andair fuel pumps
Informs owners of Andair Service Alert document, which prohibits the use of ethanol-based fuels in aircraft with Andair fuel pumps.
ID
SB-00002
Date Posted
November 5, 2020
Applies To
RV-10
Descrip­tion
Bottom Rudder Hinge Bracket Replacement
Describes change to RV-10 bottom rudder hinge bracket and method for inspection.
ID
SB-00006
Date Posted
May 6, 2020
Applies To
All RV models
Descrip­tion
Potential leaking of Kavlico pressure sensors
ID
SB 19-09-09
Date Posted
February 26, 2020
Applies To
RV-10
Descrip­tion
RV-10 updated nose gear leg
ID
SB 18-05-21
Date Posted
May 21, 2018
Applies To
All fuel injected Lycoming engine installations
Descrip­tion
Proper installation of gauge plug in fuel spider
ID
SB 18-03-30
Date Posted
March 30, 2018
Applies To
RV-10
Descrip­tion
Elevator control stop inspection
ID
MT SB 31
Date Posted
August 29, 2016
Applies To
All MT governors listed by type and serial number on page 3 and 4 which were manufactred from April 2010 until July 2013 installed on direct drive engines modified with electronic ignition or higher compression pistons.
Descrip­tion
Flyweight failures
ID
SB 16-03-28
Date Posted
March 28, 2016
Applies To
All RV-3,4,6,7,8,9,10,14
Descrip­tion
Cracking of wing aft spar web at the inboard aileron hinge bracket attach rivets.
ID
SB 14-12-22
Date Posted
December 22, 2014
Applies To
RV-6A,7A,8A,9A,10
Descrip­tion
Nose Stop Flange Installation (before further flight)
ID
SB 14-8-29
Date Posted
August 29, 2014
Applies To
RV-10
Descrip­tion
Engine Mount Elastomer Plate
ID
SB 11-9-13
Date Posted
September 13, 2011
Applies To
All RV Models
Descrip­tion
Fuel Tank Slosh Inspection
ID
SB 10-1-4
Date Posted
January 4, 2010
Applies To
RV-10
Descrip­tion
Install Door Safety Latch
ID
SB 08-6-1
Date Posted
June 1, 2008
Applies To
All RV-10 kits and completed aircraft
Descrip­tion
F-1010 bulkhead reinforcement
ID
SB 07-4-12
Date Posted
April 12, 2007
Applies To
All RV models with electric flaps
Descrip­tion
Securing flap motor rod end bearing
ID
SB 06-9-20
Date Posted
September 20, 2006
Applies To
All builders and operators of any model of a Van's Aircraft
Descrip­tion
Trim Cable Anchor
ID
SB 06-2-3
Date Posted
February 3, 2006
Applies To
RV-10
Descrip­tion
RV-10 Vertical Stabilizer   
ID
SB 04-2-1
Date Posted
February 1, 2004
Applies To
Fuel Tanks
Descrip­tion
Inspect Fuel Tanks
ID
SB 02-12-1
Date Posted
December 1, 2002
Applies To
Firewall Forward Kits and Pre-manufactured hose assemblies purchased prior to December 10, 2002
Descrip­tion
Inspect Hoses
ID
SB 96-10-1
Date Posted
October 1, 1996
Applies To
All RV Aircraft except RV-12 and RV-14
Descrip­tion
Filtered Airbox

RV-10 Notifications and Letters

ID
Date Posted
Applies To
Descrip­tion
Details
ID
SL-00097
Date Posted
March 5, 2024
Applies To
All RV's except RV-12/12iS
Descrip­tion
Use of Hartzell Propellers on RV Aircraft
Directs builders/owners to Hartzell Propeller's technical documentation, to be referenced when choosing and installing Hartzell propellers on RV aircraft.
ID
SL-00091 REV1
Date Posted
November 11, 2023
Applies To
All RV Models
Descrip­tion
Laser Cut Parts and Certification of Aircraft
Refers reader to the updated Laser-Cut Parts List as well as the Laser-Cut Parts Engineering Evaluation document; and addresses the use and inspection of these parts.
ID
SL-00078 REV 1
Date Posted
May 10, 2023
Applies To
All RV's
Descrip­tion
Vapor Lock
Discusses risks of vapor lock in high operating temperature environments and when using non-aviation fuels, as well as some information related to prevention and recognition of potential signs of vapor lock. Rev 1 updates scope of applicability to all RV aircraft running MOGAS.
ID
SL-00062
Date Posted
September 12, 2022
Applies To
All RV Aircraft
Descrip­tion
Warning Regarding Modifications to Van’s Aircraft Designs Using Van’s Aircraft Parts/Materials and/or Third-Party Parts/Materials
Letter regarding potential risks when making changes to RV aircraft that vary from the original design
ID
SL-00060
Date Posted
September 6, 2022
Applies To
All RV Models
Descrip­tion
Installation and Use of Control Stick Opening Covers
Recommended installation of stick boot covers to prevent potential unsafe operation due to interference with flight controls
ID
SL-00047
Date Posted
August 15, 2022
Applies To
All RV models
Descrip­tion
Brake Caliper O-Ring Improvement
Guidance for replacement of higher temperature O-rings in brake systems used on RV aircraft
ID
SL-00003
Date Posted
February 4, 2021
Applies To
RV-10
Descrip­tion
Optional removal of F-1054 Tank Attach Angles
Covers the optional removal of RV-10 tank attach angles where installed
ID
SL-00033 Rev 1
Date Posted
February 4, 2021
Applies To
RV-10
Descrip­tion
RV-10 Landing Gear Component Field Assessment
Directs owners to inspect and provide reports on flying RV-10 aircraft; Revised and republished 2/4/2021
ID
N 14-07-03
Date Posted
July 3, 2014
Applies To
All Van’s Aircraft RV Models
Descrip­tion
SAIB HQ-14-16 (all-metal lock nuts)
ID
N Fuel Valve Lever II Installation
Date Posted
December 20, 2011
Applies To
RV-3,4,6,7,8,9,10
Descrip­tion
Fuel Valve Lever II installation
ID
N Buying a Flying RV
Date Posted
April 19, 2011
Applies To
Buying a Flying RV
Descrip­tion
A letter to prospective buyers of flying RVs
ID
N RV-10 Door Latch Switches
Date Posted
February 13, 2008
Applies To
RV-10
Descrip­tion
Incorrect Switches in RV-10 Door Warning Light Kit
Door Latch Switches
ID
N Service Letter – Soft Rivets
Date Posted
November 26, 2007
Applies To
All RV kits
Descrip­tion
Soft Rivets
ID
N Master Switch
Date Posted
November 16, 2007
Applies To
Master Switches shipped after 10/2/2007
Descrip­tion
Inspect the back of the switch
ID
N RV-10 Motor Mount
Date Posted
January 15, 2007
Applies To
RV-10
Descrip­tion
Motor/motor mount  interference
ID
N Battery Cables
Date Posted
October 18, 2006
Applies To
All #2 battery cables
Descrip­tion
Possible battery cable terminal failure
ID
N U-1023
Date Posted
September 21, 2006
Applies To
RV-10
Descrip­tion
U-1023 nose wheel bearing spacers
ID
N Tunnel Temp
Date Posted
June 12, 2006
Applies To
RV-10
Descrip­tion
Fuselage Tunnel Temperature
ID
N RV-10 Spur Gear
Date Posted
May 18, 2006
Applies To
RV-10
Descrip­tion
Door Handle Spur Gear
ID
N 60 amp Alternator Wiring Change
Date Posted
February 13, 2006
Applies To
All users of a 60 amp Alternator
Descrip­tion
60 amp Alternator Wiring Change
ID
N Axle Nuts
Date Posted
January 9, 2006
Applies To
RV-10
Descrip­tion
Axle nut thread depth
ID
N FAB SB 05
Date Posted
October 1, 2005
Applies To
All builders and operators of any model of a Van's Aircraft kit aircraft except RV-12 
Descrip­tion
Filtered Airbox Advisory
ID
N Buying a Used RV Kit
Date Posted
August 11, 2004
Applies To
Buying a second-hand RV Kit
Descrip­tion
A letter to prospective buyers of a second-hand RV Kit  
ID
N Gascolator
Date Posted
September 4, 2003
Applies To
GAS-3 Gascolator
Descrip­tion
Recall
ID
N FAB SB 05 [superceded]
Date Posted
May 1, 2003
Applies To
Superceded by service letter October 1 2005
Descrip­tion
Filtered Airbox Advisory

RV-10 Revisions and Changes

Note: The date in a document’s title will not be the same as the date on which the document is posted. Drawing date represents the date the change was proposed/started. Date posted represents the completion/release date. Some revisions take longer than others to complete. Reasons include complexity, discovery of additional items needing revision, dependencies on other changes, validation/testing, parts fabrication, etc.

Document Key:
KAI = Kit Assembly Instructions (Number in title indicates the plans section number)
MM = Maintenance Manual
POH = Pilot Operating Handbook
PAP = Production Acceptance Procedures
FTS = Flight Training Supplement

ID
Date Posted
Applies To
Descrip­tion
Details
ID
Manual Section 15
Date Posted
December 7, 2023
Applies To
All RV Models except RV-12/12iS
Descrip­tion
Section 15: FINAL INSPECTION AND FLIGHT TEST
Section 15 - Revision 9
ID
9_10
Date Posted
September 6, 2023
Applies To
RV-10
Descrip­tion
Elevators
KAI changes related to reflect SB-00043 elevator bonding
ID
OP-64
Date Posted
May 24, 2023
Applies To
RV-10
Descrip­tion
OP-64: RV-10 FLAP MOTOR RETROFIT
Part ES-FA-PA-450-12-5 replaced with ES-FA-PA-270-12-5
ID
40
Date Posted
May 24, 2023
Applies To
RV-10
Descrip­tion
SECTION 40: FLAP SYSTEM
Part ES-FA-PA-450-12-5 replaced with ES-FA-PA-270-12-5
ID
Section 5
Date Posted
February 24, 2023
Applies To
All RV Aircraft
Descrip­tion
GENERAL INFORMATION
Updated with new information
ID
44
Date Posted
September 5, 2022
Applies To
RV-10
Descrip­tion
SECTION 44: WING ATTACHMENT
Updates related to new flap actuator
ID
39
Date Posted
September 5, 2022
Applies To
RV-10
Descrip­tion
SECTION 39: CONTROL SYSTEM
Updates related to new flap actuator
ID
26
Date Posted
September 5, 2022
Applies To
RV-10
Descrip­tion
SECTION 26: MID FUSE RIBS & BOTTOM SKINS
Updates related to new flap actuator
ID
FF5
Date Posted
October 5, 2021
Applies To
RV-10
Descrip­tion
SECTION FF5: OIL SYSTEM
Misc. updates and changes
ID
29
Date Posted
October 5, 2021
Applies To
RV-10
Descrip­tion
SECTION 29: FUSE SIDE SKINS
Misc. updates and changes
ID
23
Date Posted
October 5, 2021
Applies To
RV-10
Descrip­tion
SECTION 23: AILERON ACTUATION
Misc. updates and changes
ID
22
Date Posted
October 5, 2021
Applies To
RV-10
Descrip­tion
SECTION 22: FLAP
Misc. updates and changes
ID
15
Date Posted
October 5, 2021
Applies To
RV-10
Descrip­tion
SECTION 15: REAR SPAR
Misc. updates and changes
ID
11
Date Posted
October 5, 2021
Applies To
RV-10
Descrip­tion
Section 11: Empennage Attach
Misc. updates and changes
ID
10
Date Posted
October 5, 2021
Applies To
RV-10
Descrip­tion
SECTION 10: TAILCONE
Misc. updates and changes
ID
8
Date Posted
October 5, 2021
Applies To
RV-10
Descrip­tion
SECTION 8: HORIZONTAL STABILIZER
Misc. updates and changes
ID
6
Date Posted
October 5, 2021
Applies To
RV-10
Descrip­tion
Section 6: Vertical Stabilizer
Misc. updates and changes
ID
Filtered Air Box (FAB) Instructions
Date Posted
June 2, 2021
Applies To
320/360/540 engines with vertical induction
Descrip­tion
FAB-320-360-540 Air Box
Changes made to Filtered Air Box kit for vertical induction engines. Includes new kit parts and assembly methods for improved alignment and carb heat air door changes.
ID
35
Date Posted
April 8, 2021
Applies To
RV-10
Descrip­tion
Access Covers and Floor Panels
Updated to include missing pages (see release notes)
ID
7_10
Date Posted
November 6, 2020
Applies To
RV-10
Descrip­tion
Section 7: Rudder
Changes related to redesigned rudder bottom hinge bracket
ID
46_10
Date Posted
October 6, 2020
Applies To
RV-10
Descrip­tion
RV-10 ENGINE MOUNT & LANDING GEAR
Updated nose gear axle
ID
OP-60
Date Posted
September 24, 2019
Applies To
RV-7/7A, RV-9/9A, RV-10
Descrip­tion
Steps to install new ADAHRS mounting brackets in RV-7, RV-9, RV-10
ID
OP-56
Date Posted
September 24, 2019
Applies To
All RV Models except RV-12/iS
Descrip­tion
Changed part numbers
ID
OP-55
Date Posted
September 24, 2019
Applies To
All RV Models except RV-12/iS
Descrip­tion
Updated part numbers
ID
48_10
Date Posted
May 21, 2019
Applies To
RV-10
Descrip­tion
Changes made to include new/improved RV-10 wheelpant standoff parts.
ID
OP 38
Date Posted
September 18, 2018
Applies To
RV-10 and 14
Descrip­tion
Changes Made
ID
Section 3
Date Posted
October 2, 2014
Applies To
RV-3|RV-4|RV-6|RV-7|RV-8|RV-9|RV-10|RV-14
Descrip­tion
Changes Made
ID
FF6
Date Posted
November 4, 2009
Applies To
RV-10
Descrip­tion
SECTION FF6: EXHAUST SYSTEM
Changes Made
ID
31Q
Date Posted
December 8, 2008
Applies To
RV-10
Descrip­tion
SECTION 31Q: UPPER FORWARD FUSELAGE ASSEMBLY
Changes Made
ID
45
Date Posted
March 10, 2005
Applies To
RV-10
Descrip­tion
SECTION 45: CABIN DOORS & TRANSPARENCIES
Changes Made
ID
FF4
Date Posted
March 9, 2005
Applies To
RV-10
Descrip­tion
SECTION FF4: FUEL SYSTEM
Changes Made
ID
38
Date Posted
November 15, 2004
Applies To
RV-10
Descrip­tion
SECTION 38: RUDDER PEDALS & BRAKE SYSTEM
Changes Made
ID
25
Date Posted
November 15, 2004
Applies To
RV-10
Descrip­tion
SECTION 25: MID FUSE BULKHEADS
Changes Made

Would you like to try our new online store?