Service Information and Revisions
RV-4 Service Bulletins
ID
Date Posted
Applies To
Description
Details
ID
SB-00090
Date Posted
November 6, 2023
Applies To
All RVs equipped with SV-AP-PANEL
Description
Dynon SV-AP-PANEL Runaway Trim
Directs all owners of aircraft equipped with a Dynon SV-AP-PANEL autopilot control panel to read and review the published Dynon service bulletin document.
Directs all owners of aircraft equipped with a Dynon SV-AP-PANEL autopilot control panel to read and review the published Dynon service bulletin document.
ID
SB-00036 REV 3
Date Posted
February 28, 2023
Applies To
RV-3/4/6/7/8/9/10/14
Description
Inspect outboard elevator hinge on the horizontal stabilizer rear spar, replace if cracks found
Requires inspection of outboard elevator hinge bracket area on rear spar of horizontal stabilizer for cracks. If cracks are found, repair and replace outboard hinge brackets with new parts.
Requires inspection of outboard elevator hinge bracket area on rear spar of horizontal stabilizer for cracks. If cracks are found, repair and replace outboard hinge brackets with new parts.
ID
SB-00066
Date Posted
October 21, 2022
Applies To
All RVs with Andair fuel pumps
Description
Prohibited use of ethanol in Andair fuel pumps
Informs owners of Andair Service Alert document, which prohibits the use of ethanol-based fuels in aircraft with Andair fuel pumps.
Informs owners of Andair Service Alert document, which prohibits the use of ethanol-based fuels in aircraft with Andair fuel pumps.
ID
SB-00006
Date Posted
May 6, 2020
Applies To
All RV models
Description
Potential leaking of Kavlico pressure sensors
ID
SB 18-05-21
Date Posted
May 21, 2018
Applies To
All fuel injected Lycoming engine installations
Description
Proper installation of gauge plug in fuel spider
ID
MT SB 31
Date Posted
August 29, 2016
Applies To
All MT governors listed by type and serial number on page 3 and 4 which were manufactred from April 2010 until July 2013 installed on direct drive engines modified with electronic ignition or higher compression pistons.
Description
Flyweight failures
ID
SB 16-03-28
Date Posted
March 28, 2016
Applies To
All RV-3,4,6,7,8,9,10,14
Description
Cracking of wing aft spar web at the inboard aileron hinge bracket attach rivets.
ID
SB 14-02-05
Date Posted
February 5, 2014
Applies To
All RV-3, 4, 6/6A, 7/7A, 8/8A Flying aircraft
Description
Cracks in Elevator Spar
ID
SB 14-02-03
Date Posted
February 3, 2014
Applies To
All RV-3, 4, 6/6A, 7/7A, 8/8A Flying aircraft
Description
Superseded by SB 14-02-05
ID
SB 11-9-13
Date Posted
September 13, 2011
Applies To
All RV Models
Description
Fuel Tank Slosh Inspection
ID
SB 07-4-12
Date Posted
April 12, 2007
Applies To
All RV models with electric flaps
Description
Securing flap motor rod end bearing
ID
SB 07-2-6
Date Posted
February 6, 2007
Applies To
All RV models except RV-3, RV-10, RV-12
Description
Affixing the passenger control stick permanently
ID
SB 06-9-20
Date Posted
September 20, 2006
Applies To
All builders and operators of any model of a Van's Aircraft
Description
Trim Cable Anchor
ID
SB 06-2-23
Date Posted
February 23, 2006
Applies To
All models except RV-10
Description
Safetying of standard and flop-type fuel pickup tubes
ID
SB 04-3-1
Date Posted
March 1, 2004
Applies To
Electric Flap Drive Motor
Description
Recall
ID
SB 04-2-1
Date Posted
February 1, 2004
Applies To
Fuel Tanks
Description
Inspect Fuel Tanks
ID
SB 02-12-1
Date Posted
December 1, 2002
Applies To
Firewall Forward Kits and Pre-manufactured hose assemblies purchased prior to December 10, 2002
Description
Inspect Hoses
ID
SB 96-12-1
Date Posted
December 1, 1996
Applies To
RV-4
Description
Rudder Pedal/Cable Attach
ID
SB 96-10-2
Date Posted
October 2, 1996
Applies To
All Tailwheel RV Aircraft shipped prior to Oct 10 1996
Description
Full Swivel Tail Mechanism arm replacement
ID
SB 96-10-1
Date Posted
October 1, 1996
Applies To
All RV Aircraft except RV-12 and RV-14
Description
Filtered Airbox
RV-4 Notifications and Letters
ID
Date Posted
Applies To
Description
Details
ID
SL-00097
Date Posted
March 5, 2024
Applies To
All RV's except RV-12/12iS
Description
Use of Hartzell Propellers on RV Aircraft
Directs builders/owners to Hartzell Propeller's technical documentation, to be referenced when choosing and installing Hartzell propellers on RV aircraft.
Directs builders/owners to Hartzell Propeller's technical documentation, to be referenced when choosing and installing Hartzell propellers on RV aircraft.
ID
SL-00091 REV1
Date Posted
November 11, 2023
Applies To
All RV Models
Description
Laser Cut Parts and Certification of Aircraft
Refers reader to the updated Laser-Cut Parts List as well as the Laser-Cut Parts Engineering Evaluation document; and addresses the use and inspection of these parts.
Refers reader to the updated Laser-Cut Parts List as well as the Laser-Cut Parts Engineering Evaluation document; and addresses the use and inspection of these parts.
ID
SL-00078 REV 1
Date Posted
May 10, 2023
Applies To
All RV's
Description
Vapor Lock
Discusses risks of vapor lock in high operating temperature environments and when using non-aviation fuels, as well as some information related to prevention and recognition of potential signs of vapor lock. Rev 1 updates scope of applicability to all RV aircraft running MOGAS.
Discusses risks of vapor lock in high operating temperature environments and when using non-aviation fuels, as well as some information related to prevention and recognition of potential signs of vapor lock. Rev 1 updates scope of applicability to all RV aircraft running MOGAS.
ID
SL-00062
Date Posted
September 12, 2022
Applies To
All RV Aircraft
Description
Warning Regarding Modifications to Van’s Aircraft Designs Using Van’s Aircraft Parts/Materials and/or Third-Party Parts/Materials
Letter regarding potential risks when making changes to RV aircraft that vary from the original design
Letter regarding potential risks when making changes to RV aircraft that vary from the original design
ID
SL-00060
Date Posted
September 6, 2022
Applies To
All RV Models
Description
Installation and Use of Control Stick Opening Covers
Recommended installation of stick boot covers to prevent potential unsafe operation due to interference with flight controls
Recommended installation of stick boot covers to prevent potential unsafe operation due to interference with flight controls
ID
SL-00047
Date Posted
August 15, 2022
Applies To
All RV models
Description
Brake Caliper O-Ring Improvement
Guidance for replacement of higher temperature O-rings in brake systems used on RV aircraft
Guidance for replacement of higher temperature O-rings in brake systems used on RV aircraft
ID
Letter RV-3-4-6P1
Date Posted
November 7, 2017
Applies To
RV-3,4,6
Description
Kit Availability and Pricing Change
ID
N Service Letter 15-11-20
Date Posted
December 23, 2015
Applies To
RV-3,4,6,7,8,14
Description
RV- Aerobatic Gross Weight
ID
N 14-10-24
Date Posted
October 24, 2014
Applies To
RV-3,4,6,7,8,9
Description
Heat Muff Screen Installation
ID
N 14-07-03
Date Posted
July 3, 2014
Applies To
All Van’s Aircraft RV Models
Description
SAIB HQ-14-16 (all-metal lock nuts)
ID
N Fuel Valve Lever II Installation
Date Posted
December 20, 2011
Applies To
RV-3,4,6,7,8,9,10
Description
Fuel Valve Lever II installation
ID
N Buying a Flying RV
Date Posted
April 19, 2011
Applies To
Buying a Flying RV
Description
A letter to prospective buyers of flying RVs
ID
N Service Letter – Soft Rivets
Date Posted
November 26, 2007
Applies To
All RV kits
Description
Soft Rivets
ID
N Master Switch
Date Posted
November 16, 2007
Applies To
Master Switches shipped after 10/2/2007
Description
Inspect the back of the switch
ID
N Dynafocal II
Date Posted
April 5, 2007
Applies To
All RV's
Description
Dynafocal II motor mounts
ID
N Battery Cables
Date Posted
October 18, 2006
Applies To
All #2 battery cables
Description
Possible battery cable terminal failure
ID
N 60 amp Alternator Wiring Change
Date Posted
February 13, 2006
Applies To
All users of a 60 amp Alternator
Description
60 amp Alternator Wiring Change
ID
N FAB SB 05
Date Posted
October 1, 2005
Applies To
All builders and operators of any model of a Van's Aircraft kit aircraft except RV-12
Description
Filtered Airbox Advisory
ID
N Buying a Used RV Kit
Date Posted
August 11, 2004
Applies To
Buying a second-hand RV Kit
Description
A letter to prospective buyers of a second-hand RV Kit
ID
N FAB SB 05 [superceded]
Date Posted
May 1, 2003
Applies To
Superceded by service letter October 1 2005
Description
Filtered Airbox Advisory
ID
N Anti-Rotation Bracket
Date Posted
June 12, 2000
Applies To
All RV Aircraft Wing Tanks, also see SB 06-2-23
Description
Fuel Pick-up Tube Anti-Rotation Bracket
RV-4 Revisions and Changes
Note: The date in a document’s title will not be the same as the date on which the document is posted. Drawing date represents the date the change was proposed/started. Date posted represents the completion/release date. Some revisions take longer than others to complete. Reasons include complexity, discovery of additional items needing revision, dependencies on other changes, validation/testing, parts fabrication, etc.
Document Key:
KAI = Kit Assembly Instructions (Number in title indicates the plans section number)
MM = Maintenance Manual
POH = Pilot Operating Handbook
PAP = Production Acceptance Procedures
FTS = Flight Training Supplement
ID
Date Posted
Applies To
Description
Details
ID
Manual Section 15
Date Posted
December 7, 2023
Applies To
All RV Models except RV-12/12iS
Description
Section 15: FINAL INSPECTION AND FLIGHT TEST
Section 15 - Revision 9
Section 15 - Revision 9
ID
Section 5
Date Posted
February 24, 2023
Applies To
All RV Aircraft
Description
GENERAL INFORMATION
Updated with new information
Updated with new information
ID
Filtered Air Box (FAB) Instructions
Date Posted
June 2, 2021
Applies To
320/360/540 engines with vertical induction
Description
FAB-320-360-540 Air Box
Changes made to Filtered Air Box kit for vertical induction engines. Includes new kit parts and assembly methods for improved alignment and carb heat air door changes.
Changes made to Filtered Air Box kit for vertical induction engines. Includes new kit parts and assembly methods for improved alignment and carb heat air door changes.
ID
OP-56
Date Posted
September 24, 2019
Applies To
All RV Models except RV-12/iS
Description
Changed part numbers
ID
OP-55
Date Posted
September 24, 2019
Applies To
All RV Models except RV-12/iS
Description
Updated part numbers
ID
Section 3
Date Posted
October 2, 2014
Applies To
RV-3|RV-4|RV-6|RV-7|RV-8|RV-9|RV-10|RV-14
Description
Changes Made
